Explore
Communities in English
Advertise on Engormix

Feather Meal

Feather Meal: Its Nutritional Value And Use In Dairy And Beef Rations

Published: January 1, 2002
By: Neville J. Chandler
The following article is a special collaboration from AFMA (Animal Feed Manufacturers Association) www.afma.co.za
We thank their kind support.

Feathers – The Raw Material
The American Association of Feed Control Officials (AAFCO) defines Hydrolysed Poultry Feathers as the product resulting from the treatment under pressure of clean, undecomposed feathers from slaughtered poultry, free of additives and or accelerators. Not less than 75% of its crude protein content must be digestible by the pepsin digestibility method.

There are over 1 million tonnes of feathers produced each year in the U.S. and as the consumption of poultry meat increases so will the production of this valuable raw material. Feathers have a protein content of around 84 percent and does not suffer from the disadvantages of anti-nutritional factors, such as tannins, glucosinolates, lectins and trypsin inhibiting factors. However raw feathers are relatively insoluble and have a very low digestibility of five percent due to the high keratin content and the strong disulphide bonding of the amino acids. Fortunately with the controlled technology available to us today, we are able to convert a relatively insoluble protein into a palatable and highly digestible protein source as seen in Table 1.

Table 1. Crude Protein content and Digestibility of various proteins.

Protein
C.P. %
Ruminant Digestibility %
Dig C.P. %
Feather meal
80.4
75
60.3
Fishmeal
65.0
92
59.8
Meat & Bone
50.2
86
43.2
Soybean Meal
45.3
90
40.8
Rapeseed Meal
35.9
84
30.1
Sunflower Meal
30.1
85
25.6



Production of Feather Meal

Feather meal (FM) is produced from fresh feathers that are steam hydrolysed under high pressure and temperature (140Ý C) for a period of time sufficient to hydrolyse the chemical bonds of the feathers. Hydrolysing can be carried out in batch cookers or continuos hydrolysers and is then followed by drying. Different processing conditions such as time, temperature, pressure and moisture can have an effect on the digestibility of the protein. Basically there is a rapid increase in the time required for processing when the pressure drops below 207 kPa and a rapid fall in time as the pressure rises above 207 kPa. More recently at least one company has proposed the use of enzymes as a ‘preconditioning agent’ prior to processing in a pressure vessel. The aim of this process is to increase amino acid availability and digestibility.


Feather Meal: Its Nutritional Value And Use In Dairy And Beef Rations - Image 1


Feather meal produced under standard conditions from fresh feathers will have the following approximate analysis, Table 2:


Table 2. Typical Analysis of Feather Meal – Ewing 1997
Dry Matter
90%
Crude Protein
82%
Digestibility
75% min.
Fat
6%
Ash
4%
Crude Fibre
0.6%
Available Lysine
1.8%
Methionine + Cysteine
4.9%
TMEn
3.07 Kcal/g (12.8 MJ/kg)


A note on the digestibility values. The official method for determining the in vitro digestibility of feather meal is to use a 0.2% pepsin solution, however recent research work has shown that if a 0.002% solution is used, then the values obtained are more highly correlated with biological assays. The actual value measured is lower than with 0.2% solution however the method appears to be more sensitive and therefore of value in comparing one feather meal to another.

The Energy Value of Feather Meal
Initially work was carried out using broilers as it was considered that the NRC values were too low. Upon investigation of the initial data, Pesti (1990), found that when FM was included in diets at 40% of the ration then the energy value was low, as the animals were unable to digest and absorb the amount of protein offered. However when levels of 20% FM were added to the ration the energy value was much higher than NRC published values (2.36 kcal/g)and it was suggested that a value of 3.07 Kcal/g (12.8MJ/kg) was more appropriate. Similarly Fuller & Dale 1986 found a TME value of 3.07 Kcal/g in feather meals being used commercially in SE USA.

A prediction equation was formulated to predict the nitrogen corrected True Metabolisable Energy:


TMEn (kcal/kg DM) = 2862 + 77(% fat)

The use of this formula showed that a feather meal with 7% fat had an ME value 46 percent higher than that reported by the NRC.



The Quality of Feather Meal Protein
Much of the direct work has been carried out with broilers and as these animals are more sensitive to nutritional change. There is value in considering the results since the feather protein that bypasses the rumen will be subjected to the same digestion, absorption and utilisation that occurs in a broiler.


There is no doubt that in the 50’s and 60’s there was considerable prejudice against feather meal as a result of its low and variable digestibility which at that time was a reflection of the processing conditions. However, a considerable amount of research was carried out at several U.S. universities, (Fuller 1967, Naber et al. 1961, Summers 1969 and Thomas, 1972) which in effect demonstrated that feather meal was a useful protein supplement for inclusion in broiler diets. Corn – soya rations are equally deficient in methionine and cystine. Fuller examined whether feather meal or fish meal could be the sole source of animal protein in a corn soya diet. In order to determine how much of the total sulphur amino acid (TSSA) needs could be met by cystine in the feather meal, only enough methionine was added in each diet to keep the TSAA content equal. There were no significant differences in body weight gain or feed efficiency, demonstrating that at least half of the TSSA requirement can be met with cystine and that feather meal is a good source of this amino acid (Table 3).


Table 3. Feather Meal as a source of total sulphur amino acids.
(Fuller, 1967)
Calculated Analysis
Corn-Soya basal ration
5% Fish meal
5% Feather meal
ME (MJ/kg)
12.72
12.72
12.71
Protein %
24.2
24.3
24.2
Methionine added %
0.1
0.04
0.075
Methionine total %
0.484
0.479
0.432
Cystine %
0.373
0.378
0.425
Total Sulphur AA %
0.857
0.857
0.857
LWG (2-8 weeks) g
1660
1687
1683
FCR (feed/gain)
2.25
2.20
2.24


Summers 1969 reported on the extent to which feather meal can be used in practical broiler rations. The corn-soy and corn-soy-feather meal rations were calculated to be equal in energy and protein. Feather meal protein replaced soy protein up to the point where the first limiting amino acid became limiting in the diet. Hence the starter diet contained 6% and the finisher diet 4.1% feather meal. No differences were observed in growth or feed efficiency of chicks fed the two diets, Table 4.

Treatment
9 week weight (g)
FCR
Corn-soy diet
2077
2.27
Corn-soy-feather diet
2082
2.27
More recently Baler (1981) has demonstrated that as long as there was methionine and lysine supplementation, up to 40% of the crude protein could be supplied by feather meal without affecting growth or feed efficiency.

The data obtained with chicks indicates that upon absorption from the GI tract, that the protein in feather meal can be well utilised. An interesting observation from Cabel et al. (1986), was that when feather meal was included in rations at a level of 4-6% for 7-14 days prior to slaughter, a significant reduction in abdominal fat was observed, without affecting growth or FCR.


Amino Acid Availability
Liu et al. (1989) examined 3 samples of feather meal to determine true amino acid availability (AAA). They found that true AAA ranged from 59.2 lysine to 82.8% arginine, with an overall mean of 72.3% (Table 5). Although these values are lower than other studies they do compare well with studies by Nordheim & Coon (1984).

Table 5. True Amino Acid Availability of feather meal (Liu et al 1989).

Amino Acid
TAAA %
Lysine
59.2
Methionine
74.4
Methionine added %
0.1
Cystine
64.2
Leucine
76.9
Phenylalanine
79.2
Arginine
82.8
Overall Average
73.2 +/- 2.4


Feather Meal in Ruminant Diets
Having established from monogastric studies that FM is a valuable protein source in a post ruminal phase of digestion it would therefore be appropriate to investigate the effect of feeding feather meal to the total ruminant. A substantial amount of work with beef cattle has been conducted by Klopfenstein and his colleagues at Nebraska University with dairy trials being conducted at a number of different sites.


Dairy
Moderately producing dairy cattle have been able to obtain all of their protein needs from the passage and subsequent digestion of bacterial and protozoal protein. However with increased genetic merit and the need to produce more per cow, ways have been sought to feed both the cow and the rumen microbial population. Since the amount of bacterial protein produced is maximised, nutritionists have examined the need to supply greater amounts of protein post-ruminally by using either chemically treated or naturally occurring by-pass proteins. Rendered proteins are a source of by-pass protein and in recent times the use of feather meal has been examined in the diets of high producing dairy cattle.

Harris et al. (1997) examined the effect of three levels of feather meal on two protein content diets (Table 6).

Table 6. Effect of various levels of FM on dairy production

14%
Diet
18%
Diet
0% FM
3% FM
6% FM
0% FM
3% FM
6% FM
DMI
ns
Ns
ns
ns
ns
ns
BWt Ý
ns
Ns
ns
ns
ns
ns
MF%
ns
Ns
ns
ns
ns
ns
MY
0
++
+
0
0
0
MP%
0
-
--
0
-
--


They concluded that up to 6% FM had no negative effect on intake or body weight, a positive effect upon milk yield at the lower protein diet and a linear negative effect upon milk protein content. They suggested that the balance of amino acids, low lysine and methionine, was inadequate for maximising milk protein synthesis. Similarly Herbein and Webb (1997), found that 2.2% feather meal was not detrimental to milk production or feed intake. However, the potential for feather meal to increase milk components might be linked to the simultaneous feeding of other high bypass proteins that have complimentary amino acid profiles such as blood meal (BM) which provides more lysine and methionine. With the advent of protected methionine supplements, these combined with low cost feather protein could prove to be very economic for high producing dairy cattle.


Beef
Klopfenstein (1990) evaluated the protein value of urea, soy bean meal, FM, BM and a 50:50 combination of FM and BM when fed to 260 kg calves for a 112 day period. The basal diet was 50% ground corn cobs, 40% corn silage and 10% supplement and supplied 11.5% crude protein and 57% TDN. The urea control calves gained 376 g/day compared to BM alone which gave 735 g/day. The most efficiently used protein sources were BM and FM:BM combination compared to soy bean meal and FM. The excellent performance of the BM:FM combination was suggested as being due to the provision of lysine in the BM.


Table 7. Protein efficiency* of various sources of protein, measured in calves.

Ingredient
Protein efficiency
Blood Meal (BM)
2.92
FM:BM (50:50)
2.62
Feathe Meal (FM)
1.65
Soy Bean Meal
1.21
  • Protein efficiency measured by using the weight gain of the calves on the urea diet as the base for comparing the weight gains obtained with the other protein treatments. A high protein efficiency indicates that a protein source is being converted more efficiently to Live Weight Gain compared to a protein source that may have a low protein efficiency.

Conclusion
From monogastric studies we can see that feather meal has a high protein content with a reasonable degree of digestibility. The amino acid composition of the feather meal protein does require supplementation to balance out the low level of lysine and methionine. When incorporated into ruminant diets consideration needs to be given to the amino acid mix and supplement needs to be done, where necessary. Based upon the price of feather meal, nutritionists should consider more regular use of the commodity.



Neville J Chandler -- National Renderers´ Association, 52 Packhorse Road,Gerrards Cross, Buckinghamshire SL9 8 EF


References
Ewing, W.N. 1997 The Feeds Directory. Published by Context, UK.

Fuller, H.L. and N.M. Dale 1986. Proc 1986 Georgia Nutrition Conf., p98.

Fuller, H.L. 1967. Proc 1967 Georgia Nutrition Conf. p24.

Harris, B. Jr., Dorminey, D.E. and Van Horn, H.H. 1997 www.poultyegg.org/research/

Herbein, J.H. Jr. and Webb, K.E. Jr. 1997.>www.poultyegg.org/research/

Klopfenstein,T. 1990 Director’s Digest No 177: Fats & Protein Research Foundation

Lui, J.K., Waibel, P.E. and Noll, S.L. 1989 Poultry Science 68:1513

Naber, E.C., Touchburn, S.P., Barnett, B.D. and Morgan, C.L. 1961.

Poultry Science 40:1234.

Nordheim, J.P. and Coon, C.N. 1984. Poultry Science 63:1040

Pesti, G.M., L.D. Faust, H.L. Fuller, H.M. Dale and F.H. Benhoff 1986

Poultry Sci. 65:2258

Pesti, G.M. 1990 Fats & Proteins Research Foundation, Directors Digest 172

Summers, J.D. 1969. Feedstuffs, March16. p.36.

Thomas, O.P., bossard, E.H., Nicjolson, J.L. and Twinning, P.V. Jr. 1972. Proc. Maryland Nutrition Conf. p86.


Appendix 1: COMPARITIVE FEATHER MEAL ANALYSES (as fed basis /kg product)

NRA
NRC
INRA
ACV
MAAF
**
(USA)
(France)
(Neth.)
(UK)
Dry Matter %
91
93
93
90.6
90.7
POULTRY
ME broilers
3240
2360
2800
3150
2968
ME layers
3240
-
2800
3200
-
RUMINANT
TDN%
70
65
-
-
-
ME kcal
3350
2480
2892
-
-
PIGS
TDN %
66
62
-
-
-
DE kcal
3730
2731
3730
-
-
ME kcal
3240
2215
3240
-
-
CRUDE ANALYSIS
Crude Protein %
83
84.9
85.8
85.7
80.9
Fat %
5.0
2.9
3.5
5.4
5.8
Ash %
3.0
3.5
3.17
2.1
2.3
Crude Fibre %
1.5
1.4
-
0.0
4.3
DCP % ruminants
85
-
86
86
-
DCP % pig
85
-
75
87
-
DCP % poultry
75
-
-
77
-
MINERALS
Calcium %
0.45
0.26
0.20
0.34
0.51
Phosphorous %
0.40
0.67
0.70
0.18
0.28
Magnesium %
0.15
0.20
0.18
0.20
0.03
Potassium %
0.20
0.29
0.24
0.15
0.14
Sodium %
0.20
0.70
-
0.01
0.13
Sulphur %
1.50
1.50
0.90
-
1.64
Iron mg
70.0
76.0
70.0
-
61.00
Manganese mg
15.0
13.0
7.0
-
18.00
Selenium mg
0.10
0.84
0.30
-
0.07
Zinc mg
40.0
69.0
70.0
-
13.80
AMINO ACIDS
Lysine %
1.85
2.32
1.84
1.63
1.82
Methionine %
0.55
0.55
0.53
0.60
0.55
Cysteine %
3.50
3.24
3.55
3.34
3.76
Met + Cys %
4.05
3.79
4.08
3.94
-
Threonine %
4.00
3.97
3.91
4.20
4.10
Tryptophan %
0.50
0.52
0.43
0.51
-
Isoleucine %
4.10
4.06
3.95
4.54
4.10
Leucine %
7.00
6.94
11.58
7.03
6.90
Valine %
5.00
3.06
6.88
7.20
6.30
Histidine %
0.75
0.99
0.58
0.51
1.20
Arginine %
6.00
7.05
5.66
5.91
5.39
Glycine %
6.50
6.44
-
6.86
6.52
Serine %
10.0
9.26
-
12.34
9.80
Phenylalanine %
4.00
3.05
-
4.03
4.21
Tyrosine %
2.00
2.32
-
-
1.84

** NRA recommended values.


Related topics
Join to be able to comment.
Once you join Engormix, you will be able to participate in all content and forums.
* Required information
Would you like to discuss another topic? Create a new post to engage with experts in the community.
Create a post
Okhiomah Abu
26 de octubre de 2016
I think you need to give a full picture of your digestibility trial. Is this an in vivo or in vitro study? Are you handling the feather alone or with other ingredient? Whatever the situation I am of the opinion that the sample used for dry matter basis may be your sure bet. Although it is true that pepsin is a protein and could be denatured at 50 degree Celsius.
Hafiz Wasi Muhammad Khan
19 de octubre de 2016
Technically there should not be any negative effect unless proved otherwise
Adeoluwa Adetunji
17 de octubre de 2016

I have a question in relation to determination of feather meal protein digestibility.
For me to express protein digestibility on dry matter basis, I'm looking at using the dry sample that I dried for moisture determination of the feather meal for the pepsin digestibility.
My question is this, will drying at 50 degree celcius for 24 hr have any negative effect on the digestibility of the feather meal protein or not?
Thank you.

Janvier HABIMANA
30 de septiembre de 2015

I am new on this group, so I am interested in producing feeds. How can I get feed formulation based on nutrient requirement of domestic animals?

shahbaz
5 de agosto de 2015

We are not the regular user of feather meal in ruminants feed specifically in beaf but few days before may be due to mixing of feather meal it is incorporated in regular feed and there is mortality of two calves happen and after postmartum there is a feather meal in rumen and farm manager supposed it had happened due to F.M inclusion. plz suggest me wheather it is possible?

Leon
20 de agosto de 2013

As many researches show, 3-5% feather meal can be used in many poultry diet.

Join Engormix and be part of the largest agribusiness social network in the world.
LoginRegister