Explore
Communities in English
Advertise on Engormix

Effects of urea and molasses supplementation on chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and bagasse silages as alternative silage crop compared with maize silage in the arid areas

Published: November 9, 2014
By: Shahabodin Zafari Naeini1, Mohammad Khorvash2, Ebrahim Rowghani3*, Alireza Bayat4 and Zahra Nikousefat5 (1 Shiraz University 2 Isfahan University of Technology 3 Islamic Azad University 4 Animal Production Research, MTT Agrifood Research Finland 5 Razi University)
Summary

This study was planned to determine the chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and sweet sorghum bagasse silages treated with urea and molasses. Treatments were maize silage (MS), sweet sorghum silage (SS), sweet sorghum bagasse silage (BS) and/or urea and molasses supplemented (10 and 50 g/kg dry matter (DM) basis, respectively) SS and BS. Triplicate silage samples were prepared for each treatment in laboratory silos. Fresh sweet sorghum and its bagasse had greater (P<0.01) DM and NFC, but lower (P<0.01) CP and a NDF concentrations compared with maize. After 90 d of ensiling, similar results were found in produced silages. The SS and BS had lower protein “A” fraction but greater protein “C” fraction (P<0.01) compared with MS. Treating of SS and BS with urea or molasses resulted in an increased (P<0.05) in pH. Orthogonal comparisons showed adding urea increased CP, lactate, ammonia nitrogen (NH3-N) concentrations, and pH value but decreased NFC (P<0.01). Adding molasses to SS and BS silages increased DM, WSC, NFC, pH (P<0.01) and in vitro digestibility of DM (P<0.05) while caused a decrease in a NDF, ADF, acetate (P<0.01) and ethanol (P<0.05). Adding of urea or urea plus molasses to SS and BB resulted an increase in protein “A” fraction (P<0.01) but a decrease in protein “C” fraction (P<0.01). Therefore, simultaneous application of urea and molasses improved the nutritional quality, DM digestibility, protein fractionations and fermentation characteristics of SS and BS and offered a potential alternative silage crop compared with maize in the arid areas.

Keywords: Additives; fermentation characteristics; protein fractionation; sweet sorghum; sweet sorghum bagasse

 

Introduction
Sweet sorghum (Sorghum bicolor var. saccharatum) is a C4 plant with high photosynthetic activity, resistant to drought and salinity (Almodares et al., 2008), contains a high level of energy (Negro et al., 1999) and can be cultivated in most tropical areas. Also, sweet sorghum stem juice can be used for production of ethanol as a bio fuel (Almodares and Hadi, 2009). There has been a growing tendency to produce ethanol from sweet sorghum juice in Iran. Therefore there is a concern about the disposal of the remaining sorghum bagasse (Filya, 2003). Sorghum bagasse (like stem juice) can be used for bio fuel production however; it is not an economically viable process so far (Drapcho et al., 2008). Therefore, in this study it was attempted to preserve this residue for long term and also produce potentially usable feed for ruminants.
Ensiling is a suitable method for forage conservation and is aimed at minimizing nutrient wastage by enhancing the growth of lactic acid producing bacteria (Baytok et al., 2005). However, inadequate crude protein in sorghum (55 to 90 g per kg DM) results in long fermentation time (Marrero et al., 2000) which may increase the temperature in the lower layers of the silage. Urea can be used to increase nitrogen concentration and improve the fermentation quality of the sorghum forage (Filya, 2001). Since soluble proteins could not be utilised optimally in the absence of adequate water soluble carbohydrates (WSC). Molasses, a source of WSC, is often used along with urea to help preventing silage instability (Jaurena and Pichard, 2001). Also, molasses prevents increase in silage temperature and poor aerobic stability of produced silage (Soderholm et al., 1998). Molasses has also been added to the silages to increase dry matter (DM) concentration, fermentation rate and production of lactic acid (McDonald et al., 1991).
Because the protein content of forages, silages or grains used in animal feeding are sometimes inadequate to meet the needs of the animal, protein supplements (e.g., adding urea in silages) become essential. Consequently, analysis for protein fractions or crude protein in a feed sample or silages is important. Also, there are very few reports about the sweet sorghum bagasse silage and its quality. However, the effects of additives such as urea and molasses on sweet sorghum and sorghum bagasse silages composition, fermentation characteristics and CNCPS protein fractions have not been investigated before. Therefore the present study was performed to investigate the quality of ensiled sweet sorghum and its bagasse and the effects of supplementation of urea and/or molasses on their quality in central Iran condition. 
Materials and Methods
Plant material
Sweet sorghum (Sorghum bicolor var. saccharatum) was planted on 5 June 2011 in Isfahan University Research Farm and harvested after 120 d having a mean DM concentration of 331 g/kg fresh weight. The study location, crop management and fertilizers adding for sweet sorghum were the same as mentioned by Zafari Naeini et al. (2014). Maize was harvested after 70 d (early dent) at a mean DM concentration of 177 g/kg fresh weight which is a rather common practice in Iran. For maize, there was 16 cm distance between the bushes in a row and 76 cm distance between the rows and plant population was 70 to 80 thousands/ha. The plants were cut 15-20 cm from ground level. About 100 kg of maize forage and 200 kg of sweet sorghum forage were harvested and the materials were randomly divided into different batches needed for the preparation of treatments. To obtain sorghum bagasse, the grain clusters were separated by hand and the leaves by a special apparatus. The resulted stems were extracted using an apparatus having two pairs of rollers to reduce the weight by 200±20 g/kg fresh weight. Extracted stems along with separated leaves were chopped into 2-3 cm pieces. The same chaffing process was performed for whole maize and sweet sorghum forages. Sweet sorghum and maize silages were prepared from whole plants including stems, seeds and leaves.
Ensiling procedure
Whole sorghum and maize plants and sorghum bagasse were ensiled in PVC cylindrical shape containers with 4.0±0.2 kg capacity (50 cm height × 16 cm diameter).The density was 521±62.5, 543±48.5 and 451±29.0 kg/m3 for fresh maize, sweet sorghum and sorghum bagasse forages, respectively. Urea and/or molasses (10 and 50 g/kg on DM basis, respectively) were added to the silage batches prior to filling whenever appropriate. To ensure precise mixing of urea and molasses to the plant material, first a small portion of the material were mixed with urea or molasses and then the portion was mixed with whole batch thoroughly. The laboratory silos had a 2-cm layer of sand in the bottom to help drainage process. A tap and hose were attached to the bottom of the silos to drain the effluent. After filling the silos, plant material were pressed using a pressing apparatus to ensure expelling of the air. The silos were closed tightly and the lids were lubricated with oil to be sealed effectively. The laboratory silos were placed in a dark room with average temperature of 18°C until opening after 90 d of preservation.
Treatments
The experimental treatments were as follow: 1) maize silage (MS), 2) sweet sorghum silage (SS), 3) sweet sorghum silage plus urea (SSU), 4) sweet sorghum silage plus urea and molasses (SSUM), 5) sweet sorghum bagasse silage (BS), 6) sweet sorghum bagasse silage plus urea (BSU), 7) sweet sorghum bagasse silage plus urea and molasses (BSUM). Three replicates were used for each treatment and in total twenty one laboratory silos were used in this experiment.
Sampling and chemical analysis of fresh and ensiled forages
Fresh forages
After chopping, 500 g of fresh forage was dried at 55°C for 48 h in triplicate for each treatment and then the dried material was ground to pass a 1 mm screen and stored in dark vacuum plastic bags at room temperature (20±2°C) for chemical analysis and in vitro incubation. The silages were evaluated after 90 d of ensiling. Before evaluation, 5 cm from the top and bottom ends of the silage in each silo were discarded and the remaining material was mixed thoroughly to ensure uniformity. Then a 2 kg fresh sample was transferred into vacuum plastic bags and frozen at - 20°C for subsequent analysis.
Chemical analysis
A 30 g sample of fresh silage was mixed with 270 ml distilled water (1:9 ratio) and blended using a kitchen blender for 50 to 60 seconds at high speed. The extract was then filtered through four layers of cheese cloth and the pH was determined using a digital pH meter (Metrohm 744, Switzerland). Some of the extract was stored at -20°C until analyzed for acetic acid, lactic acid, ethanol and NH3-N.
The frozen silage samples were oven-dried at 55°C for 48 h and ground through a 1 mm sieve for determination of chemical composition. The ether extract (EE), crude protein (CP) and ash were measured according to AOAC (1999) and the NFC was calculated (g/kg DM) using the following formula (Ishler and Varga, 2001):
NFC=1000-[ash+EE+CP+aNDF-NDIP]
Where NDIP is neutral detergent insoluble protein. The WSC was measured by phenol-sulfuric acid method (Masuko et al., 2005). The UV absorption was recorded at 470 nm wavelength using a spectrophotometer (Jasco V-570 UV/Vis/NIR spectrophotometer, Japan). Ethanol, propionic, butyric and acetic acid were measured by gas chromatography (Crompak, Model CP 9002, The Netherlands) as described by Playne (1985). The determination of lactic acid was carried out by high-performance liquid chromatography (HPLC) method developed by Megias et al. (1993). Ammonia-N (NH3-N) was measured (Kjeltec Auto 1030 Analyzer, Sweden) in 50 ml of fresh silage extracts (without digestion) filtered through what man filter paper #1 (Filya, 2003). The fibre sections, NDF assayed with amylase and expressed inclusive of residual ash (aNDF) and acid detergent fibre (ADF) were measured using heat-resistant alpha-amylase and sodium sulphite (for starch and protein degradation, respectively) according to Van Soest et al. (1991) and acid detergent lignin (ADL) by hydrolysis method using 720 g/kg sulphuric acid (Van Soest and Wine, 1968).
Determination of in vitro digestibility of DM and ADF
In order to determine in vitro digestibility of DM (IVDDM) and ADF (IVDADF), 0.5 g of dried silages samples, ground through a 1 mm sieve, were transferred into heat sealed F57 filter bags of Ankom and were incubated along with four empty bags as blanks. The buffer solutions A and B were prepared according to the instruction for Ankom DaisyII Incubators (Ankom Technology, Macedon, NY, USA). An equal volume of the rumen fluid was obtained from 3 non-lactating Holstein cows (750.0±10 kg, consuming a total mixed ration) about 4 h after morning feeding and mixed. A maintenance ration (AFRC, 1992) was fed in equal portions two times per d (07:00 and 19:00) consisting of 490 g/kg silage (1:1 MS:SS), 100 g/kg concentrate (containing 5 g/kg urea), 400 g/kg chopped alfalfa and 10 g/kg molasses. The rumen fluid was immediately transported to the laboratory in a carbon dioxide flask and mixed using a kitchen blender for 30-60 seconds under anaerobic conditions (presence of CO2). The fluid was then filtered through four layers of cheesecloth. Each Ankom jar contained 400 ml filtered rumen fluid, 25 bags, 266 ml B solution (15 g Na2CO3, 1 g Na2S.9H2O per litre), 1330 ml A solution (10 g KH2PO4, 0.5 g MgSO4.7H2O, 0.5 g NaCl, 0.1 g CaCl2.2H2O and 0.5 g urea per litre)at pH=6.8. The jars were then placed in the Ankom DaisyII device for 48 h at 39.5°C. At completion of incubation, the jars were removed and the fluid was drained. The bags were rinsed thoroughly with cold tap water with minimal mechanical agitation until the water was clear. The rinsed bags were transferred into the Ankom200 Fibre Analyzer, aNDF was determined based on the ANKOM protocol and the aNDF weight (W3) was recorded. The bags were dried at 60°C for 48 h and IVDDM was calculated as:
IVDDM (g/kg DM) = 1000{1-[W3-(W1×C1)]/(W2×DM)} ×1000
Where W1 is the bag tare weight, W2 is the sample weight, W3 is the final bag weight after in vitro and sequential neutral detergent solution treatment and C1 is the blank correction factor (final oven-dried weight/original blank bag weight). The following equation was used for determination of final ADF (ADFFinal) after 48 h of incubation in Ankom DaisyII and washing with ADF solution in Ankom200 Fibre Analyzer:
ADFFinal(g/kg DM) = {[W4-(W1×C1)]/(W2×DM)}×1000
Where W1, W2 and C1 have been previously described and W4 is the final bag weight after in vitro and sequential acid detergent solution treatment. In vitro digestibility of ADF was calculated using the following equation:
IVDADF (g/kg total ADF) = {(A1-A2)/A1}×1000
Where: A1 and A2 are the primary and final ADF (g/kg DM), respectively.
Determination of the protein fractions
Protein fractionation was performed as described by Licitra et al. (1996). Non-protein nitrogen (A fraction) was calculated as the difference between the sample nitrogen content and precipitated true protein nitrogen. The B1 fraction was estimated using boratephosphate buffer and sodium azide solution. The NDIP and acid-detergent insoluble protein (ADIP or C fraction) were measured using neutral detergent and acid detergent solutions, respectively. The B3 fraction was calculated by subtracting the amount of protein remaining in the sample washed with neutral detergentand protein remaining in the sample washed with acid detergent. TheB2 fraction was calculated as CP – (A+B1+B3+C).
Statistical analysis
This experiment was done as a completely randomized design with seven treatments and three replicates. The data were analyzed using the General Linear Model (GLM) procedure of the Statistical Analysis System (SAS, 2003) based on the following model:
Yij=μ + Ti+ eij
Where μ is the overall mean for each parameter, Ti is treatment effect (i = 1–7) and eij is the residual. Percentage data were transformed into Arcsin before analysis and then reconverted to original unit for showing in Tables. The effects of urea (SS and BS versus SSU and BSU), molasses (SSU and BSU versus SSUM and BSUM) or urea plus molasses (SS and BS versus SSUM and BSUM) were assessed using orthogonal comparisons. 
Results
Fresh forages
Sorghum forage had higher DM, WSC and NFC (P<0.05) but lower CP, EE, aNDF and ADF concentrations (P<0.01) compared with the maize forage (Table 1). Sorghum bagasse had higher DM, aNDF and ADF but lower CP and NFC concentrations than the sorghum forage. There were no differences in the concentrations of ADL, ash and IVDDM (Table 1) and protein A fraction (Table 2) between whole sweet sorghum, maize forages, and sweet sorghum bagasse (P>0.05). Fraction B1 was greater in bagasse compared with maize and fraction B2 was greater in maize forage than in sorghum and its bagasse. B3 fraction was greater in bagasse compared with maize and sorghum forages (P<0.01). Fraction C was the highest (P<0.01) in sorghum plant, medium in sorghum bagasse and the lowest in maize forage. 
Table 1: Chemical composition (g/kg DM) of fresh maize forage, sweet sorghum forage and sweet sorghum bagasse
Effects of urea and molasses supplementation on chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and bagasse silages as alternative silage crop compared with maize silage in the arid areas - Image 1 
Table 2: Protein fractions (g/kg of crude protein) of fresh maize forage, sweet sorghum forage and sweet sorghum bagasse based on CNCPS method
Effects of urea and molasses supplementation on chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and bagasse silages as alternative silage crop compared with maize silage in the arid areas - Image 2
Chemical composition of silages
The chemical composition of silages at 90 d of ensiling is shown in Table 3. Sweet sorghum silage (SS) and sweet sorghum bagasse silage (BS) had higher DM concentrations compared with MS (P<0.01). Urea, as an additive, increased CP but decreased the NFC concentrations of the silages (P<0.01). There were no significant differences (P>0.05) in ADL and EE concentrations among silages. Adding molasses decreased NDF and ADF concentrations (P<0.01) while increased DM, WSC, NFC and ash concentrations (P<0.01). Addition of both urea and molasses increased DM, WSC (only for SSUM silage) and CP concentrations of the silages compared with the silages without any additive. The least effluent (P<0.01) was observed for bagasse silages. 
Table 3: Chemical composition (g/kg DM) of maize, sorghum and sorghum bagasse silages with or without additives after 90 days of ensiling
Effects of urea and molasses supplementation on chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and bagasse silages as alternative silage crop compared with maize silage in the arid areas - Image 3
Fermentation characteristics of silages
Fermentation characteristics of silages after 90 d of ensiling are shown in Table 4. All silages had pH values lower than 4.0. The pH was not different between MS, SS and BS silages. However, SSUM and BSUM silages had the highest pH values compared with other silages (P<0.05). There was no significant difference between silages in NH3-N/total N (NH3-N/N) concentration. Adding urea or urea plus molasses increased NH3-N (P<0.01) concentration compared with their respective control silages, where the concentrations of ethanol, lactic acid and acetic acid were higher in MS than other silages (P<0.01). Adding urea plus molasses reduced ethanol and acetate (P<0.05) while increased lactate concentration (P<0.01). Propionic and butyric acid peaks were not detected in any of the silages.
Protein fractionation of silages
Characteristics of protein fractions based on CNCPS at d 90 of ensiling are shown in Table 5. Ureatreated silages had the highest protein A fraction (P<0.01). Fractions B1 and B3 values were not different among the silages (P>0.05). Fraction C value was not different among MS, SSU, SSUM, BSU and BSUM, while the highest C value was found in SS and BS silages. Urea treatment decreased the B2 and C fractions (P<0.01). 
Discussion
The low DM concentration of maize plant (177 g/kg DM; Table 1) might be due to the early stage of harvesting which resulted in low silage DM concentration of MS (203 g/kg DM; Table 3). Higher IVDADF of fresh maize compared with sorghum (100 g/kg difference) arising primarily from earlier maturity of maize compared with sorghum during the harvest time. As a result, in spite of higher ADF concentration of fresh maize (50 g/kg DM difference) compared with sorghum forage, no significant difference was found between fresh maize and sorghum in vitro digestibility of DM.
Sweet sorghum bagasse in the current study had rather different chemical composition than those reported in the literature. When sweet sorghum stalks were pressed by rollers to extract stem juice, fibrous bagasse remains which contained 270 to 480 g/kg cellulose, 190 to 240 g/kg hemicelluloses, and 90 to 320 g/kg lignin (Kim and Day, 2011; Cunningham et al., 1986). In a study by Anandan et al. (2012), sweet sorghum bagasse with leaf residues had lower CP (40 g/kg) and higher NDF (690 g/kg) contents, but lower IVDDM (543 g/kg DM) compared with our results. The discrepancy in chemical composition of sweet sorghum bagasse in the current experiment and the reported values (i.e. more CP and less NDF) can be attributed to either lower juice extraction or lower maturity stage of sweet sorghum in the current experiment. 
Table 4: Fermentation characteristics (g/kg DM) of maize, sorghum and sorghum bagasse silages with or without additives after 90 days of ensiling
Effects of urea and molasses supplementation on chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and bagasse silages as alternative silage crop compared with maize silage in the arid areas - Image 4 
Table 5: Protein fractions (g/kg of crude protein) of silages from maize, sorghum and sorghum bagasse with or without additives based on CNCPS method after 90 days of ensiling
Effects of urea and molasses supplementation on chemical composition, protein fractionation and fermentation characteristics of sweet sorghum and bagasse silages as alternative silage crop compared with maize silage in the arid areas - Image 5
Silage pH is an important factor in the long-term stability of ensiled plant material. A pH value below 4.0 is considered satisfactory for long-term storage of ensiled material (Jaster, 1995) as observed for all the silages in the current experiment. Results of the present study and other reports (Bolsen et al., 1985; Hinds et al., 1992) showed that urea increases silage pH and concentrations of NH3-N and CP. Ensiling forages with urea increased concentrations of amino acids such as alanine, aspartic acid, glutamic acid, valine and isoleucine (Lessard et al., 1978). Soluble proteins could not be utilised optimally in the absence of adequate WSC, therefore molasses, a source of WSC, is often used along with urea to help preventing silage instability (Jaurena and Pichard, 2001). Many studies reported decreasing pH with the addition of molasses (Aminah et al., 2001; Baytok et al., 2005) while simultaneous addition of urea and molasses resulted in higher pH values (Keskin et al., 2005; Balakhial et al., 2008). This effect can be partly explained by the buffering capacity of silages which increases with the addition of urea (Berger et al., 1994). However, Guney et al. (2007) reported that the addition of 10 g/kg urea or 10 g/kg urea plus 50 g/kg molasses to the silage had no significant effect on pH.
Increased NH3-N in the silages containing urea could be as a result of increased degrading activities of bacteria. Balakhial et al. (2008) observed that supplementing forages such as canola with urea can decrease silage quality by increasing pH value and NH3-N concentration. Ammonia-N(NH3-N) also can arise from other sources, such as the reduction of nitrates and nitrites, the action of lactic acid bacteria (Bergen et al., 1991), which are capable of amino acid fermentation (Brady, 1960). Silage is considered excellent when the NH3-N/N is below 7 g/100 g, and considered good when the NH3-N/N is between 7 and 10 g/100 g (Romero, 2004). In our experiment, the NH3-N/N ranged from 11.3 to 18.8 g/100 g with the greatest numbers for silages having urea plus molasses which indicates that the NH3-N/N is greater than good silage. Nevertheless, the silages had good visual appearance, odour and colour, low final pH (i.e. 3.7– 3.9), and absence of butyric and propionic acids indicating good fermentation (McDonald et al., 1991).
Bolsen et al. (1985) and Singh et al. (1996) reported that the addition of urea to sorghum silage increased the concentration of acetic acid whereas Hinds et al. (1992) reported no effect. Keskin et al. (2005) reported that the addition of 5 g/kg urea to sorghum silage had no effect on propionic acid concentration and 5 g/kg urea or 5 g/kg urea plus 40 g/kg molasses increased the butyric acid concentration. It is well known that the addition of molasses to silage increases lactic acid concentration (Bolsen et al., 1985; Hinds et al., 1992; Bolsen et al., 1996) and resultsin lower pH and lower NH3-Nconcentration (Ojeda and Montejo, 2001). However, in the present study, the addition of molasses had no effect on lactate concentration. Decreasing aNDF and ADF concentrations of silages due to the addition of molasses may be as a result of lower fibre concentrations in the molasses (Bingol and Baytok, 2003).
Increased IVDDM due to adding molasses to silages is consistent with Seoane et al. (1992) and Petit and Veira (1994) reporting that the addition of molasses to the silage increased digestibility due to increasing cell wall hydrolysis. These results are contrary to Keskin et al. (2005) who reported that the addition of urea or urea plus molasses to sorghum silages decreased the IVDDM compared with the control. They attributed this decrease to increased organic matter (soluble carbohydrates) losses in the urea and molassescontaining silages. Di Marcoa et al. (2009) reported that the IVDDM value at 24 h of incubation was the only indirect methodology that matched the corresponding in vivo data in all silages. High NDF digestibility of the silage is expected to be associated with increased feed intake and milk production (Oba and Allen, 2005). Each one percentage increase in estimated in vitro NDF degradability of maize silage based diet would increase the DM intake and milk production by 170g/d and 250g/d, respectively (Allen, 2000). Also there are positive effects of adding 6 g/kg DM urea to the lactating dairy cow feeding maize silage based diet and microbial protein synthesis was maximized in these animals (Boucher et al., 2007).
In the CNCPS, NPN is assumed to be converted rapidly to ammonia and does not contribute to the ruminal peptide pool, which is derived from the degraded true protein fractions. NPN is determined as the nitrogen passing into the filtrate after precipitation with a protein specific reagent (Licitra et al., 1996). When trichloroacetic acid (TCA) is used as a protein precipitant, peptides of less than ten amino acids units are not precipitated. Therefore, they are allocated to the NPN fraction. Because peptides and amino acids can stimulate microbial growth greater than ammonia (Russell et al., 1992), these solubilized peptides contribute to microbial growth, and allocating them to the NPN pool, results in the underestimation of microbial growth and MP allowable milk (Aquino et al., 2003).
When forages are ensiled, bacteria ferment the forage and breaks forage protein down into smaller fractions, which are more degradable by rumen bacteria. This process called proteolysis. Some researchers (Messman et al., 1994) estimated that only 9% of forage macro-protein molecules remain after fermentation. The decreases in the proportions of B1, B2 and B3 fractions in the silages containing urea or urea plus molasses can be derived from the proportional effect of urea addition, which appears in the form of NPN (fraction A). The content of crude protein A fraction increased (P<0.01) from fresh to ensiled forage (mean 397.3 vs. 524.66 g/kg of CP, respectively), especially in maize silages. As a result, the content of true protein (B1+B2+B3) decreased (P<0.05) similar to data reported for red clover by Krawutschke et al. (2011), they showed that the most important source of variation for all crude protein fractions was generally the ensiling stage, except for fraction C.
In current study, ensiling increased the B1 fraction in maize and sweet sorghum bagasse (P<0.05) while adding urea or molasses or both of them simultaneously had no effect on B1 fraction which is soluble in buffer and is mostly available to ruminal microorganisms (Krishnamoorthy et al., 1982). The B2 fraction has a slower degradation rate than B1 fraction and some of it escapes to the lower gut. Our results demonstrated that ensiling had most decreasing impact (P<0.01) on the B3 fraction which has an even slower ruminal degradation rate than other B fractions, especially in bagasse silages (233 vs. 51 g/kg CP). The C fraction which considered unavailable in gastrointestinal tract (Krishnamoorthy et al., 1982), showed a reduction when urea plus molasses was added to the silages. 
Conclusions
Higher DM and NFC concentrations in sweet sorghum plantand sweet sorghum bagasse compared with maize plant and similarity in pH and IVDDM between MS, SS and BS silages indicated that sweet sorghum plant and sweet sorghum bagasse can produce silages with good nutritional value in arid environment of central Iran. Also, similar pH values between MS, SS and BS silages but lower NH3-N, lactate, acetate and ethanol in SS and BS silages compared with MS, indicated better fermentation pattern and lower DM losses in SS and BS silages compared with MS. Simultaneous addition of urea and molasses improves the nutritional quality of sweet sorghum and sweet sorghum bagasse silages by increasing CP, WSC, NFC and IVDDM but reducing ethanol, aNDF and protein C fraction. 
References
AFRC. 1992. Nutritive requirements of ruminant animals: Protein. Nutrition Abstracts and Reviews (Series B), 62: 787-835.
Allen, M.S. 2000. Effects of diet on short-term regulation of feedintake by lactating dairy cattle. Journal of Dairy Science, 83: 1598-1624.
Almodares, A. and Hadi, M.R. 2009. Production of bioethanol from sweet sorghum: A review. African Journal of Agricultural Research, 4: 772-780.
Almodares, A., Hadi, M.R. and Ahmadpour, H. 2008. Sorghum stem yield and soluble carbohydrates under phonological stages and salinity levels. African Journal of Biotechnology, 7: 4051-4055.
Aminah, A., Abu Bakar, C. and Izham, A. 2001. Silages from tropical forage: Nutritional quality and milk production. FAO Electronic Conference on Tropical Silage. http://www.fao.orgIDOCREP/ 005/X8486E/x8486eOd.htm
Anandan, S., Hazda, Z, Khan, A.A., Ravi, D. and Michael, B. 2012. Feeding value of sweet sorghum bagasse and leaf residues after juice extraction for bio-ethanol production fed to sheep as complete rations in diverse physical forms. Animal Feed Science and Technology, 175: 131-136.
AOAC. 1999. Official Methods of Analysis, Assoc. Offic. Anal. Chem. Intern., Gaithersburg, MD.
Aquino, D.L., Tedeschi, L.O., Lanzas, C., Lee, S.S. and Russell, J.B. 2003. Evaluation of CNCPS predictions of milk production of dairy cows fed alfalfa silage. In Proceedings of the Cornell nutrition conference for feed manufacturers. New York State College of Agriculture & Life Sciences, Cornell University. Pp: 137-150.
Balakhial, A., Naserian, A.A., Heravi Moussavi, A., Eftekhar Shahrodi, F. and Vali Zadeh, R. 2008. Changes in chemical composition and in vitro DM digestibility of urea and molasses treated whole crop canola silage. Journal of Animal and Veterinary Advances, 7: 1042-1044.
Baytok, E., Aksu, T., Karsli, M.A. and Muruz, H. 2005. The effect of formic acid, molasses and inoculant as silage additives on corn silage composition and ruminal fermentation characteristics in sheep. Turkish Journal of Veterinary and Animal Sciences, 29: 469-474.
Bergen, W.G., Byrem, T.M. and Grant, A.L. 1991. Ensiling characteristics of whole-crop small grains harvested at milk and dough stages. Journal of Animal Science, 69: 1766-1774.
Berger, L.L., Fahey, G.C., Bourguin, L.D. and Titgemeyer, E.C. 1994. Modification of Forage Quality After Harvest In: George, C. and Fahey, J.R. (editors), “Forage Quality Evaluation and Utilization” American Society of Agronomy Inc., Lincoln.
Bingol, N.T. and Baytok, E. 2003.The effects of some silage additives in sorghum silage on the silage quality and ruminal degradability of nutrients. I. The effects on silage quality. Turkish Journal of Veterinary and Animal Sciences, 27: 15-20.
Bolsen, K., Ilg, H., Axe, D. and Smith, R. 1985. Urea and Limestone Additions to Forage Sorghum Silage. Kansas State University Cattlemen’s Day 85 Report of Progress, 82-84, Manhattan, KS.
Bolsen, K.K., Ashbell, G. and Weinberg, Z.G. 1996. Silage fermentation and silage additives. Asian- Australasian Journal of Animal Sciences, 9: 483- 493.
Boucher, S.E., Ordway, R.S., Whitehouse, N.L., Lundy, F.P., Kononoff, P.J. and Schwab, C.G. 2007. Effect of incremental urea supplementation of a conventional corn silage-based diet on ruminal ammonia concentration and synthesis of microbial protein. Journal of Dairy Science, 90: 5619-5633.
Brady, C.J. 1960. Redistribution of nitrogen in grass and leguminous fodder plants during wilting and ensilage. Journal of the Science of Food and Agriculture, 11: 276- 284.
Cunningham, R.L., Carr, M.E. and Bagby, M.O. 1986.Hemicellulose isolation from annual plants.In Proceedings of the 8th Symposium on Biotechnology for Fuels and Chemicals. (editors) C.D. Scott, Gatlinburg, TN., John Wiley & Sons, NY, pp: 159-168.
Di Marcoa, O.N., Ressia, M.A., Arias, S., Aello, M.S. and Arzadún, M. 2009. Digestibility of forage silages from grain, sweet and bmr sorghum types: Comparison of in vivo, in situ and in vitro data. Animal Feed Science and Technology, 153: 161-168.
Drapcho, C.M., Nhuan, N.P. and Walker, T.H. 2008. Biofuels Engineering Process Technology., The McGraw-Hill companies, Inc, USA. Filya, I. 2001. Silage fermantation. Ataturk University Agricultural department review, 32: 87-93.
Filya, I. 2003. The effect of Lactobacillus buchneri and Lactobacillus plantarum on the fermentation, aerobic dtability, and ruminal degradability of low dry matter corn and sorghum silage. Journal of Dairy Science, 86: 3575-3581.
Guney, M., Demirel, M., Celik, S., Bakici, Y. and Levendoglu, T. 2007. Effects of urea, molasses and urea plus molasses supplementation to sorghum silage on the silage quality, in vitro organic matter digestibility and metabolic energy contents. Journal of Biological Sciences, 7: 401-404.
Hinds, M., Brethour, J., Bolsen, K. and Harvey, I. 1992. Inoculant and Urea-Molasses Additives for Forage Sorghum Silage.Kansas State University Cattlemen’s Day, 11-15.Manhattan, KS.
Ishler, V. and Varga, G. 2001. Carbohydrate Nutrition ForLactating Dairy Cattle. Pennsylvania State University, Code #: DAS 01-29, pp: 1-11.
Jaster, E.H. 1995. Legume and grass silage preservation.In K.J. Moore and M.A. Peterson (editors), Post-harvest physiology and preservation of forages. CSSA-ASA, Madison, WI, Pp: 91-115.
Jaurena, G. and Pichard, G. 2001. Contribution of storage and structural polysaccharides to the fermentation process and nutritive value of lucerne. Animal Feed Science and Technology, 92: 159- 173.
Keskin, B., Yilmaz, I.H., Karsli, M.A. and Nursoy, H. 2005. Effects of urea or urea plus molasses supplementation to silages with different sorghum varieties harvested at the milk stage on the quality and in vitro dry matter digestibility of silages. Turkish Journal of Veterinary and Animal Sciences, 29: 1143-1147.
Kim, M. and Day, D.F. 2011. Composition of sugar cane, energy cane, and sweet sorghum suitable for ethanol production at Louisiana sugar mills, Journal of Industrial Microbiology and Biotechnology, 38: 803-807.
Krawutschke, M., Weiher, N., Gierus, M., Thaysen, J. and Taube, F. 2011. The effect of cultivar on the crude protein fractions of fresh, wilted and ensiled red clover. In Proceedings of the 16th Symposium of the European Grassland Federation Gumpenstein, Austria, Pp: 256-258.
Krishnamoorthy, U., Muscato, T.V., Sniffen, C.J. and Van Soest, P.J. 1982. Nitrogen fractions in selected feedstuffs. Journal of Dairy Science, 65: 217-225.
Lessard, R.G., Erfle, J.D., Sauer, F.D. and Mahadevan, S. 1978. Protein and free amino acid patterns in maize ensiled with or without urea. Journal of the Science of Food and Agriculture, 29: 506-512.
Licitra, G., Hernandez, T.M. and Van Soest, P.J. 1996. Standardization of procedures for nitrogen fractionation of ruminant feeds. Animal Feed Science and Technology, 57: 347-358.
Marrero, L., Castro, A., Arias, A. and Delgado, D. 2000. Rendimiento en grano, forraje y caracterización nutritiva del forraje de sorgo granífero en monocultivoo asociado con soya. In: resúmenes, L.D.P.Y. (Ed.), XII Seminario Científico Internacional. 30 Aniversario del INCA de 14 al 17 de noviembre, Cuba, Pp: 77.
Masuko, T., Minami, A., Iwasaki, N., Majima, T., Nishimura, S.I. and Lee, Y.C. 2005. Carbohydrate analysis by a phenol–sulfuric acid method in microplate format. Analytical Biochemistry, 339: 69-72.
McDonald, P., Henderson, A.R. and Heron, S.J.E. 1991.The biochemistry of silage.2ndedition, ChalcombePublications, Marlow, Bucks, UK.
Megias, M.D., Martinez-Teruel, A., Gallego, J.A. and Nunez, J.M. 1993. Chemical changes during ensiling of orange peel. Animal Feed Science and Technology, 43: 269-274.
Messman, M.A., Weiss, W.P. and Koch, M.E. 1994. Changes in total and individual proteins during drying, ensiling, and ruminal fermentation of forages. Journal of Dairy Science, 77: 492-500.
Negro, M.J., Solano, M.L., Ciria, P. and Carrasco, J. 1999. Composting of sweet sorghum bagasse with other wastes. Bioresource Technology, 67: 89-92.
Oba, M. and Allen, M.S. 2005. In vitro digestibility of forages. In: Proceedings of the Tri-State Dairy Nutrition Conference. The OhioState University, Columbus, OH, USA, pp: 81-91.
Ojeda, F. and Montejo, I. 2001. Conservación de morera (Morus alba) como ensilaje. I. Efecto sobre los compuestos nitrogenados. Revista Pastos y Forrajes, 24: 147-155.
Petit, H.V. and Veira, D.M. 1994. Digestion characteristic of beef steers feed silage and different levels of energy with or without protein supplementation. Journal of Animal Science, 72: 3213-3220.
Playne, M.J. 1985. Determination of ethanol, volatile fatty acids, lactic and succinic acids III fermentation liquids by gas chromatography. Journal of the Science of Food and Agriculture, 36: 638-644.
Romero, L.A. 2004. Ensilaje de soja, calidad en forrajes conservados. Manual de actualización técnica. Merco Láctea, San Francisco, Córdova, Argentina, pp: 40-41.
Russell, J.B., O'Connor, J.D., Fox, D.G., Van Soest, P.J. and Sniffen, C.J. 1992. A net carbohydrate and protein system for evaluating cattle diets: I. Ruminal fermentation. Journal of Animal Science, 70: 3551-3561.
SAS. 2003. SAS Statistical Analysis Systems 2003. User’s Guide. SAS Institute Incorporation, Cary, NC, USA.
Seoane, J.R., Christen, A.M., Veira, D.M. and Fontecilla, J. 1992. Performance of growing steers fed quack grass hay supplemented with canola meal. Canadian Journal of Animal Science, 72: 239-247.
Singh, A., Edward, J.C., Mor, S. and Singh, K. 1996. Effect of inoculation of lactic acid bacteria and additives on ensiling MP chari (Sorghum bicolor), Indian Journal of Animal Science, 66: 1159-1165.
Soderholm, C.G., Otterby, D.E., Linn, J.G., Hansen, W.P., Johnson, D.G. and Lundquist, R.G. 1998. Addition of ammonia and urea plus molasses to high moisture snapped ear corn at ensiling. Journal of Dairy Science, 71: 712-721.
Van Soest, P.J. and Wine, R.H. 1968. Determination of lignin and cellulose in acid-detergent fiber with permanganate. Journal of the Association of Official Analytical Chemists, 51: 780-785.
Van Soest, P.J., Robertson, J.B. and Lewis, B.A. 1991. Methods for dietary fiber, neutral fiber and nonstarch polysaccharides in relation to animal nutrition. Journal of Dairy Science, 74: 473-481.
Zafari Naeini, S., Khodambashi Emami, N., Rowghani, E. and Bayat, A. 2014. Influence of ensiling time on chemical copmpsition, fermentation characteristics,gas production and protein fractions of sweet sorghum silage. Research Opinions in Animal and Veterinary Sciences, 4: 286-293.
Related topics
Authors:
Ebrahim Rowghani
Shiraz University
Follow
Join to be able to comment.
Once you join Engormix, you will be able to participate in all content and forums.
* Required information
Would you like to discuss another topic? Create a new post to engage with experts in the community.
Create a post
Join Engormix and be part of the largest agribusiness social network in the world.
LoginRegister