Explore
Communities in English
Advertise on Engormix

Tunnel Operation Tips for Houses with Young Birds

Published: August 8, 2016
By: Michael Czarick, Brian Fairchild College of Agricultural and Environmental Sciences, Cooperative Extension, University of Georgia
It is widely understood that tunnel ventilation is a necessity when it comes to keeping market-age broilers comfortable during hot weather. Air speeds of 600 ft/min or more combined with evaporative pad cooling of ten degrees or more have proven to not only help keep heat stress related mortality to a minimum, but enable the birds to continue to eat and grow during even the hottest summer weather. But, if we want to insure maximum bird performance, health and comfort throughout a flock, tunnel ventilation needs to be viewed as an important tool that producers can and should use any time birds appear heat stressed, whether they are 60 days old or five.
Though tunnel ventilation is in general not required at the beginning of a flock, during periods of extreme heat when house temperatures may be running 5 to 10o F above desired target temperatures and young birds appear heat stressed (i.e, lying stretched out, panting), it use is advisable. The goal in this situation is not to utilize the full cooling potential of a house’s tunnel ventilation system, but rather to use just enough tunnel fan and evaporative cooling pad capacity to keep young birds comfortable.
Tunnel Operation Tips for Houses with Young Birds - Image 1
Figure 1 is a thermal image taken of young birds in a house utilizing side wall inlet ventilation on a very hot afternoon. The house temperature was approaching 100o F and chick ear lobe temperatures, a very good indicator of deep body temperature, were over 108o F. Normally, chicken ear lobe temperatures are a couple of degrees below the normal deep body temperature of approximately 106o F. When they are above 106o F it is very likely the chicks are heat stressed. In this particular incidence this correlation between elevated ear lobe temperatures and deep body temperatures was confirmed by the fact that young birds were panting heavily and laying flat with their wings spread, and very few birds were eating and drinking (Figure 2). Though the likelihood of mortality was low, the fact is bird performance and health in this situation were very likely to suffer.
 
1) Since the total amount of heat produced by a flock of young birds is relatively little, the number tunnel fans required to produce an acceptable air exchange rate is substantially lower than with market-age birds. With market-age birds approximately 9 to 10 cfm/ft2 of tunnel fan capacity (approximately equivalent to an air exchange rate of once per minute) is required to insure that there is less than a 5o F temperature rise from tunnel inlet to the tunnel fans (Figure 3). Since the total heat production of younger birds is substantially lower than market-age birds, the required tunnel fan capacity is also substantially lower, typically between 1.5 to 3 cfm/ft2 of floor space. For example, in a 40' X 500' house, approximately 200,000 cfm of tunnel fan capacity may be required (40' X 500' X 10 cfm/ft2 ) in a house with market-age birds. When the birds are two weeks old only 70,000 cfm of tunnel fan capacity is typically required (40' X 500' X 3.5 cfm/ft2 ). It is important to realize that the minimum tunnel fan capacities depicted in Figure 3 are estimations. Factors such as bird placement density, house construction, insulation levels and outside temperature can affect the required tunnel fan capacity. As a result, the temperature difference from the pads to the fans should be closely monitored and if it exceeds four to five degrees, additional tunnel fan capacity should be utilized.
 
Tunnel Operation Tips for Houses with Young Birds - Image 2
2) In addition to obtaining the proper air exchange rate to insure a minimal temperature difference between the tunnel inlet and fan ends of a house, it is equally important that a proper air speed is maintained to insure adequate bird heat removal/cooling. Since young birds tend to be fairly well spread out, have minimal feather cover, and have a high surface area/body weight ratio, very little air speed is required to remove excess heat from the birds to keep them comfortable. As a result, it is generally recommended that air speeds when in tunnel ventilation are kept below 300 ft/min during the first couple weeks of the flock. Producing too much air speed may not necessarily harm the birds when house temperatures are in the nineties, but it can result in excessive energy usage.
Tunnel Operation Tips for Houses with Young Birds - Image 3
Figure 4 was taken in the same house shown in Figure 1 fifteen minutes after the house was switched from side wall inlet ventilation to tunnel ventilation. Thirty percent of the houses tunnel fans were operating (1.5 cfm/ft2 ) producing an air speed of approximately 200 ft/min. Within a short time ear lobe temperatures dropped below 104o F, the majority of the birds stopped panting and feeding/drinking activity increased.
3) As with older birds it is important that the birds are spread out evenly throughout the house. The greater the amount of space between the birds the lower the amount of air speed required to keep the birds cool. If the birds are in partial house, moving the birds to full house should be considered.
4) Tunnel doors/curtains can be either partially opened or fully opened when tunnel ventilating younger birds. Care must be taken not to close the tunnel doors/curtains too much because it can result in excessive air movement in the tunnel inlet area. If a partial tunnel opening is to be used it should be opened roughly proportional to the number of tunnel fans operating. If one-third of the tunnel fans are being used, then the tunnel doors/curtains should be opened at least one-third of their maximum opening.
5) If the birds still appear heat stressed after switching into tunnel ventilation mode a very limited amount of water should be added to a house’s evaporative cooling pads. If too much water is added to the pad system it is very likely that the incoming air temperature will fall below the desired house temperature which can result in tunnel fans turning off, the house transitioning from tunnel back into side wall inlet mode, and possibly even the house’s heating system turning on.
To prevent over cooling of the incoming air it is advisable not to operate an evaporative cooling pad system’s circulation pumps solely off of house temperature. This is because the amount of cooling produced by a pad system does not instantly stop when the circulation pumps are turned off. When water is added to a dry pad the amount of cooling produced continues to increase over the first ten minutes as water flowing over the surface of the pad wicks into the interior of the pad. Even if the circulation pumps are turned off after operating a couple of minutes or less, the incoming air temperature will continue to fall for another two to ten minutes as water slowly wicks into the interior of the pad.
Tunnel Operation Tips for Houses with Young Birds - Image 4
Figure 5 illustrates how the incoming air temperature will continue to fall even after a pad system’s circulation pumps shut off. The incoming air temperature was 94o F prior to the pumps turning on. The circulation pumps were briefly turned on from 2:09 pm to 2:11 pm. Within one minute of the pads turning on, the incoming air temperature dropped approximately two degrees to 92o F. A minute later the incoming air temperature was 89o F and the circulation pumps turned off. Even though there was no water circulating over the pads, the incoming air temperature continued to fall another five degrees to 83o F. Had there been week-old birds in the house this ten-degree reduction in house temperature would have likely resulted in an over-cooling of the young birds. For the most part with young birds the objective is typically to keep the incoming air temperature from exceeding the low 90's.
To limit the cooling produce by an evaporative cooling pad system it is best, if possible, to wet only one half of the pad on each side of the house. Furthermore, circulation pumps should operate not only based on temperature but an interval timer as well. Once the house temperature becomes excessive circulation pumps should be set to operate less than ten seconds out of very ten minutes. It is better to start with a minimal amount of runtime and increase it after a cycle or two if the cooling is insufficient because if the pad becomes excessively wet it can be difficult for the next hour or more to avoid over cooling of incoming air. Just as with older birds, it is important to keep in mind that air speed is the primary means of cooling young birds and the evaporative cooling system should be used as a secondary tool. Evaporative cooling pads should be used not a substitute for proper air exchange rates and air speed.

This article was originally published at UGA Cooperative Extension Poultry Housing Tips Vol. 28 no. 4, 2016. 
Tunnel Operation Tips for Houses with Young Birds - Image 5
Related topics
Authors:
Mike Czarick
University of Georgia
Follow
Dr. Brian D. Fairchild
University of Georgia
Follow
Influencers who recommended :
Martin Rishoj
Join to be able to comment.
Once you join Engormix, you will be able to participate in all content and forums.
* Required information
Would you like to discuss another topic? Create a new post to engage with experts in the community.
Create a post
Mike Czarick
University of Georgia
16 de agosto de 2016
Sorry but as an engineer your question is out of my area of expertise.
Mike Czarick
University of Georgia
9 de agosto de 2016

Humidity would play a significant role in the need to tunnel-ventilate young birds. The higher the humidity the more likely you would need to tunnel-ventilate a house. The guidelines provided in the article should provide a starting point for house operation. The best way to know if you need more air speed is to monitor the front to rear temperature differential as well as the birds. If the temperature rise becomes excessive or the the birds appear heat stressed fan capacity/air speed should be increased. Sorry to say there is no formula for optimal house operation.

Wijaya Saputra
16 de agosto de 2016
Thank a lot for your article very useful for take decision in the field . if we done vaccination by intra ocular as example ND live vaccine sometime hear snoring in the night time when we control specially at Bird at age 5 weeks old. What we may to increase wind speed after vaccine in the night time ? please you give me suggestion. Thank you very much on attention.
Kuncoro
10 de agosto de 2016
Thanks so much for your information GBU
Moustafa Elshazly
9 de agosto de 2016
good excellent article, what`s the role of humidity in this formula ? and how to make coordination between Humidity, temperature and air speeds at the same time?
Join Engormix and be part of the largest agribusiness social network in the world.
LoginRegister